I want to set my Scirocco on fire!

[matt at safearmy.com (matt)]

yes the pump is running. What you say makes sense to me. today the car ran longer than normal but it was much cooler today than it has been. So what do i need to do to check if the line is being pinched?

-------Original Message-------
> From: "Allyn" <amalventano1@tds.net>
> Subject: Re: I want to set my Scirocco on fire!
> Sent: 24 Apr 2005 19:24:46
>
>  if there is a clog/pinch in the return line (from reservoir to tank), air
>  will build up in the reservoir over ~15 mins and once enough air collects
>  the main fuel pump sucks up the air slug and the car dies. once both pumps
>  stop, fuel siphons from the tank and refills the reservoir.
>  
>  reason mine did it: return line was pinched between the tank and the body.
>  turns out this happened during the fuel tank recall/replacement. in my
>  situation it would only happen on really hot days - the tank would expand
>  just that much more against the body, just enough to pinch the line shut.
>  
>  a faulty transfer pump can cause the same effect. i see you replaced yours,
>  but did you verify that it actually runs?
>  
>  hth
>  Al
>  
>  ----- Original Message -----
>  From: "matt" <matt@safearmy.com>
>  To: <scirocco-l@scirocco.org>
>  Sent: Sunday, April 24, 2005 1:51 PM
>  Subject: I want to set my Scirocco on fire!
>  
>  
>  >I posted before that my 87 8v Auto has been having some issues. The car
>  >will run for about 15-25 min then start to sputter and die. It will start
>  >right back up but will die quickly. So far I have replaced the transfer
>  >pump. main pump, fuel pump relay, coil and cleaned up the grounds and added
>  >a thicker ground from the valve cover to the firewall. I'm really not sure
>  >if this is a fuel issue or electrical.  The fuel pumps were used so I guess
>  >it possible that the transfer pump is bad which was what I first thought.
>  >Someone said it could be a distributor problem I'm going to try to swap
>  >that this week. Any other thoughts would be great.
>  > Matt
>  > 1981 Mars Red
>  > 1984 Wolfsburg
>  > 1987 8v Auto
>  > Louisville, Ky
>  >
>  > _______________________________________________
>  > Scirocco-l mailing list
>  > Scirocco-l@scirocco.org
>  > http://neubayern.net/mailman/listinfo/scirocco-l
>  >
-------Original Message-------