RE: RE: [engine] idle hunting...

["dan" <danws69@earthlink.net>]

no- it's valve tapping....trust me....

Dan
'81 Rabbit Sport Truck
'87 16v Scirocco
'00 Jetta
Tam-pa, FL
http://home.earthlink.net/~danws69/index.html

-----Original Message-----
From: Fry, Larry [mailto:LEF@chem-tronics.com]
Sent: Friday, October 19, 2001 13:19
To: sixteen.volt@gte.net
Cc: danws69@earthlink.net; roc "E-mail"
Subject: RE: RE: [engine] idle hunting...


Neal-
What Dan's describing is not "lifter" tap, it is rod knock.
...my opinion and I'm stickin' to it.

Larry  sandiego16V

-----Original Message-----
From: Neal Tovsen [mailto:res00ffj@verizon.net]
Sent: Friday, October 19, 2001 10:10 AM
To: Fry, Larry
Cc: danws69@earthlink.net; roc "E-mail"
Subject: Re: RE: [engine] idle hunting...


But what Dan's describing is oil starvation from the RPMs falling so low
(near 0). This describes lifter tapping (the correct term is "cam follower"
on an OHC engine), and has nothing to do with the block. However, if the
tapping doesn't immediately go away when RPMs go back to normal, it may
indicate new lifters are needed or that his oil pump is weak. Neither are
terribly difficult or expensive, but that's another story and I presume
isn't the problem...

Neal


>
> From: "Fry, Larry" <LEF@chem-tronics.com>
> Date: Fri, 19 Oct 2001 08:56:41 -0700
> To: danws69@earthlink.net, "roc (E-mail)" <scirocco-l@scirocco.org>
> Subject: RE: [engine] idle hunting...
>
> lifters tap....rods knock.  Sounds like you will be rebuilding the lower
end
> soon.
>  I've been chasing the same idle problem since I bought my "87 16V two
years
> ago.  If you uncover the cause, let the list know!
>
> on the same post; my in-car voltmeter reads one volt lower than my
> multimeter says the batt/charging voltage really is (e.g. 12.5V vs.
13.5V).
> Anyone got the reason/fix?
>
> Larry  sandiego16V
>
> -----Original Message-----
> From: dan [mailto:danws69@earthlink.net]
> Sent: Friday, October 19, 2001 8:18 AM
> To: roc (E-mail)
> Subject: [engine] idle hunting...
>
>
> ...are there any on-line tech procedures done for this subject yet? I've
> heard some talk about an air/bypass valve? I recently had that funky
2-piece
> hose crap out on me, and aside from the high idle, it wasn't doing this up
&
> down crap.
>
> My current situation is:
> -car starts fine
> -when coming to a stop sign/light, rpms drop (alt light comes on briefly)
> rpms rise to 2000, if I don't tap the gas, it'll drop way low and die.
>
> NOW GET THIS:
> If I have the a/c on, idle is PERFECT. Luckily I'm in Florida, but
> occasionally we get nice weather...
>
> I really HAVE to fix this because of the side effects of the idle problem:
> -when it drops super-low my oil pressure drops too low and then I get a
> scorching case of lifter-knock.
> -alternator stops charging properly, it charges, but not at the level that
> it started at (i.e. 10.5~11 VDC) - (yes, I've verified my gauge by
sticking
> my multi-meter on the battery terminals).
>
>
>
> Sorry for the longer-than-usual post from me.
>
> Dan
> '81 Rabbit Sport Truck
> '87 16v Scirocco
> '00 Jetta
> Tam-pa, FL
> http://home.earthlink.net/~danws69/index.html
>
>
> --
> Email LIST problems to: scirocco-l-probs@scirocco.org.
> To unsubscibe send "unsubscribe scirocco-l" in the message to
> majordomo@scirocco.org
>
> [Disclaimer]This e-mail is strictly confidential and intended solely for
the
> addressee. It may contain information which is covered by legal,
> professional, or other privilege. If you are not the intended addressee
you
> must not use, disclose, or copy this transmission. This E-mail is not
> intended to impose nor shall it be construed as imposing any legally
binding
> obligation upon GKN Aerospace Chem-tronics Inc. and/or any of its
> subsidiaries or associated companies. Neither GKN Aerospace Chem-tronics
> Inc. nor any of its subsidiaries or associated companies gives any
> representation or warranty as to the accuracy or completeness of the
> contents of this E-mail. GKN Aerospace Chem-tronics Inc. shall not be held
> liable to any person resulting from the use of any information contained
in
> this E-mail and shall not be liable to any person who acts or omits to do
> anything in reliance upon it.
>
>
> --
> Email LIST problems to: scirocco-l-probs@scirocco.org.
> To unsubscibe send "unsubscribe scirocco-l" in the message to
majordomo@scirocco.org
>
>

[Disclaimer]This e-mail is strictly confidential and intended solely for the
addressee. It may contain information which is covered by legal,
professional, or other privilege. If you are not the intended addressee you
must not use, disclose, or copy this transmission. This E-mail is not
intended to impose nor shall it be construed as imposing any legally binding
obligation upon GKN Aerospace Chem-tronics Inc. and/or any of its
subsidiaries or associated companies. Neither GKN Aerospace Chem-tronics
Inc. nor any of its subsidiaries or associated companies gives any
representation or warranty as to the accuracy or completeness of the
contents of this E-mail. GKN Aerospace Chem-tronics Inc. shall not be held
liable to any person resulting from the use of any information contained in
this E-mail and shall not be liable to any person who acts or omits to do
anything in reliance upon it.


--
Email LIST problems to: scirocco-l-probs@scirocco.org.
To unsubscibe send "unsubscribe scirocco-l" in the message to majordomo@scirocco.org