RE: FI Start problems

["Zack LeGrow" <zlegrow@home.com>]

Where is the hot pulse relay located? My service manual makes 
no mention of it at all.. And how do I tell if it needs replacement? 
Maybe its time to use my Haynes manual to hold my sunroof up... 
The phone book that's there now is proving to be more useful.


On 4 Nov 01, at 8:23, Patrick Bureau wrote:

> 
> Ah well that is not a COLD start problem but a Hot Start problem.
> 
> Bentley p5-6 (85-92) CIS troubleshooting
> 
> 2. hot start -engine starts hard or fails to start when warm.
> probable causes
> a. Hot start pulse relay faulty, Test hot start pulse relay and
> replace it if necesseray b. Cold start valve leaking or operating
> continuously, test cold start valve and thermo time switch c. fuel
> pressure incorrect, Test warm control pressure. replace control
> pressure regulator is required. d. inpect air flow sensor plate rest
> position. and adjust if required (1.9mm below lowest edge of bowl) e.
> test residual fuel pressure, replace fuel pump check valve or fuel
> accumulator as necessary f. inspect fuel lines and connections,
> correct leaks as required.
> 
> I would suggested the pressure regulator on teh from of teh block
> myself,
> 
> -----Original Message-----
> From: owner-scirocco-l@scirocco.org
> [mailto:owner-scirocco-l@scirocco.org]On Behalf Of Zack LeGrow
> Sent: Sunday, November 04, 2001 2:56 AM
> To: scirocco-L@scirocco.org
> Subject: RE: FI Start problems
> 
> 
> Warm starting. Run it for ten minutes and then shut it off, then try
> starting again. It'll turn over great, but never ever catch. Have to
> wait about half an hour.
> 
> On 3 Nov 01, at 21:01, Patrick Bureau wrote:
> 
> > I must of missed the original post what are your cold start
> > symptoms, does it start then stalls? do it start but idles up and
> > down ? what does it do again, I just had to deal with 2 different
> > cold start problem related at the same time and perhaps I can help
> > you with a solution
> >
> > Patrick
> >
> > -----Original Message-----
> > From: owner-scirocco-l@scirocco.org
> > [mailto:owner-scirocco-l@scirocco.org]On Behalf Of Zack LeGrow
> > Sent: Saturday, November 03, 2001 7:51 PM
> > To: scirocco-L@scirocco.org
> > Subject: Re: FI Start problems
> >
> >
> > Okay. I replaced the cold start valve and it still does it.
> > Fuel pumps are fine,filter is fine, air cleaner is fine. Thermotime
> > switch is fine.
> >
> > I'm running out of ideas...
> >
> >
> > On 3 Nov 01, at 9:33, Zack LeGrow wrote:
> >
> > > I'm having this problem right now with my 86 8v. May be the
> > > thermotime switch (Haynes Manual suggestion, I know I know,
> > > Haynes is bad, but I can't find any other ones) but I just
> > > replaced it and still it doesn't help...
> > >
> > > Going to the junk yard today to rip out some fuel system piecesof
> > > anything they have there and see what happens. Zack LeGrow '86
> > > Scirocco 8V - The Red Baron
> > >
> > > --
> > > Email LIST problems to: scirocco-l-probs@scirocco.org.
> > > To unsubscibe send "unsubscribe scirocco-l" in the message to
> > > majordomo@scirocco.org
> > >
> >
> >
> > Zack LeGrow
> > '86 Scirocco 8V - The Red Baron
> >
> > --
> > Email LIST problems to: scirocco-l-probs@scirocco.org.
> > To unsubscibe send "unsubscribe scirocco-l" in the message to
> > majordomo@scirocco.org
> >
> >
> > --
> > Email LIST problems to: scirocco-l-probs@scirocco.org.
> > To unsubscibe send "unsubscribe scirocco-l" in the message to
> > majordomo@scirocco.org
> >
> 
> 
> Zack LeGrow
> '86 Scirocco 8V - The Red Baron
> 
> --
> Email LIST problems to: scirocco-l-probs@scirocco.org.
> To unsubscibe send "unsubscribe scirocco-l" in the message to
> majordomo@scirocco.org
> 
> 
> 
> --
> Email LIST problems to: scirocco-l-probs@scirocco.org.
> To unsubscibe send "unsubscribe scirocco-l" in the message to
> majordomo@scirocco.org
> 


Zack LeGrow
'86 Scirocco 8V - The Red Baron

--
Email LIST problems to: scirocco-l-probs@scirocco.org.
To unsubscibe send "unsubscribe scirocco-l" in the message to majordomo@scirocco.org